小型攪拌機驅動裝置的作用是驅動混凝土貯罐轉動，它由取力器、萬向軸、液壓泵、液壓馬達、操縱閥、液壓油箱及冷卻裝置組成。如果這部分因故障停止工作，混凝土貯罐將不能轉動，這會導致車內混凝土報廢，嚴重的甚使整罐混凝土凝結在罐內，造成混凝土攪拌運輸車報廢。所以說小型攪拌機的驅動裝置是否可靠很關鍵。

The driving device of small mixer is used to drive the concrete storage tank to rotate. It is composed of power take-off, universal shaft, hydraulic pump, hydraulic motor, control valve, hydraulic oil tank and cooling device. If this part stops working due to failure, the concrete storage tank will not be able to rotate, which will lead to the scrapping of the concrete in the vehicle, and even cause the whole tank of concrete to condense in the tank, resulting in the scrapping of the concrete mixer truck. Therefore, whether the driving device of the small mixer is reliable is critical.

1.小型攪拌機削部件是故障部件。應及時填充潤滑脂，并經常檢查磨損情況，及時修理和更換。車隊?wèi)?yīng)該有一個備用的萬向軸組件，以確保在發生故障時能夠在幾分鐘內恢復。

1. The cutting parts of small mixer are faulty parts. The lubricating grease shall be filled in time, the wear condition shall be checked frequently, and the repair and replacement shall be carried out in time. The fleet should have a spare cardan shaft assembly to ensure recovery within a few minutes in the event of a failure.

2.確保液壓油清潔。攪拌一體車的工作環境不好，須防止臟水泥砂進入液壓系統。應根據手冊的要求定期更換液壓油。一旦檢查發現水或沙子混入液壓油中，就須立即停止液壓系統并更換液壓油。

2. Make sure the hydraulic oil is clean. The working environment of the mixer truck is not good, so it is necessary to prevent dirt proof cement sand from entering the hydraulic system. The hydraulic oil shall be replaced regularly according to the requirements of the manual. Once water or sand is found to be mixed in the hydraulic oil, the hydraulic system must be stopped immediately and the hydraulic oil must be replaced.

3.確保液壓油冷卻裝置有效。定期清洗液壓油散熱器，避免散熱器被水泥堵住，檢查散熱器電風扇是否正常運行，防止液壓油溫度超標。只要液壓部件確保液壓油清潔，通常幾乎沒有故障，但制造商具有不同的使用壽命。

3. Ensure that the hydraulic oil cooling device is effective. Clean the hydraulic oil radiator regularly to prevent the radiator from being blocked by cement. Check whether the radiator fan operates normally to prevent the hydraulic oil temperature from exceeding the standard. As long as the hydraulic components ensure that the hydraulic oil is clean, there are usually few failures, but the manufacturers have different service lives.

一般來說，如果小型攪拌機的驅動裝置由于故障停止工作，混凝土儲罐將不能正常旋轉，這將導致車輛中的混凝土報廢，甚整個罐體混凝土將在罐內冷凝，造成攪拌一體車要報廢。因此，驅動裝置是否可靠是在使用中須高度重視的問題。關注我們http://www.dqpme.cn，帶您了解更為詳細的內容！

Generally speaking, if the driving device of the small mixer stops working due to failure, the concrete tank will not rotate normally, which will lead to the scrapping of the concrete in the vehicle, or even the whole tank concrete will condense in the tank, resulting in the scrapping of the mixer. Therefore, whether the driving device is reliable is a problem that must be paid great attention to in use. Follow us http://www.dqpme.cn , to guide you to more detailed content!